Optimasi Pemberian Lumpur Aktif dan Dolomit dalam Pengolahan Limbah Cair Pabrik Kelapa Sawit

Authors

  • Erni Widayanti Jurusan Budidaya Tanaman Perkebunan - Politeknik Negeri Lampung
  • Rijadi Subiantoro Jurusan Budidaya Tanaman Perkebunan - Politeknik Negeri Lampung
  • Yonathan Parapasan Jurusan Budidaya Tanaman Perkebunan - Politeknik Negeri Lampung

DOI:

https://doi.org/10.25181/jaip.v6i1.671

Abstract

The palm oil mill effluent (POME) generally has very high of BOD and COD contents, so it must be processed before it is drained to the body water. The purpose of this research was to determine the capability of active sludge and dolomite rate and the combination both of them in reducing the palm oil industry liquid waste. This research was conducted in December 2016 until January 2017 at Chemical Analysis Laboratory, State Polytechnic of Lampung. This research consists of two factors. First factor was the use of active sludge (without active sludge and 1 kg of active sludge), and the second factor was dolomite rate (0,3%, 0,6%, and 0,9% dolomite).The results obtained were calculated bassed on average repetitions then at compared with the value of initial analysis and quality standard, but the COD value is calculated based on the percentage of the reduction value, and all the observed values are presented in the graph. The results showed that the 1 kg active sludge treatment was more effective in degrading the wastewater than with no active sludge. The increased dose of dolomite to 0.9% combined with 1 kg of active sludge will be followed by an increase in pH (6,23) and DO (0,26 mg.l-1), but decrease COD to 53,7%, TSS to 810 mg.l-1, turbidity value to 700 NTU, and potassium content to 4865 mg.l-1.                                                 Keywords: chemical oxygen demand, dissolved oxygen, palm oil mill effluent, total suspended solid, turbidity

Downloads

Download data is not yet available.

References

Budianta, D. (2005). Potensi Limbah Cair Pabrik kelapa Sawit Sebagai Sumber Hara Untuk Tanaman Perkebunan (Potential of Palm Oil Mill Effluent for Organic Fertilizer on Plantation Plant). Dinamika Pertanian, 20(1), 273-282.

Sani, E. Y. (2006). Pengolahan air limbah tahu menggunakan Reaktor anaerob bersekat dan aerob (Doctoral dissertation, program Pascasarjana Universitas Diponegoro).

Irvan, B. T., Vincent, M., & Tandean, Y. (2012). Pengolahan Lanjut Limbah Cair Kelapa Sawit Secara Aerobik Menggunakan Effective Microorganism Guna Mengurangi Nilai TSS. Jurnal Teknik Kimia USU, 1(2), 27-30.

Isyuniarto, Usada, W., & Purwadi, A. (2007). Degradasi limbah cair industri kertas menggunakan oksidan ozon dan kapur. In: Prosiding PPI – PDIPTN. pp 55-60.

Krismawati, R., Ahdia, R., & Soetrisnanto, D. (2013). Pengolahan Efluen Pond Fakultatif Anaerobik IPAL Industri Kelapa Sawit secara Fakultatif Anaerobik-Fitoremediasi sebagai Pre-Treatment Media Tumbuh Algae. Jurnal Teknologi Kimia dan Industri, 2, 286-294.

Lubis, A. U. (2008). Kelapa Sawit (Elaeis guineensis Jacq.) di Indonesia. Marihat: Pusat Penelitian Kelapa Sawit.

Makmur, M., Kusnoputranto, H., Moersidik, S. S., & Wisnubroto, D. S. (2013). Pengaruh limbah organik dan rasio n/p terhadap kelimpahan fitoplankton di kawasan budidaya kerang hijau Cilincing. Jurnal Teknologi Pengelolaan Limbah, 15(2), 51-64.

Moertinah, S., Yuliastuti, R., & Yuliasni, R. (2010). Peningkatan kinerja lumpur aktif dengan penambahan karbon aktif dalam pengolahan air limbah industri tekstil pewarnaan dengan zat warna indigo & sulfur. Journal of Industrial Research (Jurnal Riset Industri), 4(1), 23-33.

Nursanti, I., Dedik, B., Napoleon, A., & Yakup, P. (2013, November). Pengolahan Limbah Cair Pabrik Kelapa Sawit Kolam Anaerob Sekunder I menjadi Pupuk Organik melalui Pemberian Zeolit. In: Seminar Nasional Sains & Teknologi V. Lembaga Penelitian Universitas Lampung. pp. 616-626.

Reynolds, T. D. (1982). Unit Operations and Processes in Environmental Engineering. Belmont, California: Wadsworth Inc.

Sanjaya, R., Subiantoro, R., & Supriyatdi, D. (2017). Efektivitas Kombinasi Lumpur Aktif dan Natrium Bikarbonat (NaHCO3) dalam Pengelolaan Limbah Cair Industri Tebu (Saccharum officinarum L.). Jurnal Agro Industri Perkebunan, 5(1), 39-56.

Rakhmawati, D. (2012). Remediasi Limbah Proses Pewarna Naptol Jeans Dengan Sistem Lumpur Aktif Menggunakan Bakteri Indigenus.Unpublished undergraduate thesis, Universitas Atma Jaya,Yogyakarta.

Yusuf, G. (2008). Bioremediasi limbah rumah tangga dengan sistem simulasi tanaman air. Bumi Lestari, 8(2), 136-144.

Downloads

Published

2018-05-29

How to Cite

Widayanti, E., Subiantoro, R., & Parapasan, Y. (2018). Optimasi Pemberian Lumpur Aktif dan Dolomit dalam Pengolahan Limbah Cair Pabrik Kelapa Sawit. Jurnal Agro Industri Perkebunan, 6(1), 19-28. https://doi.org/10.25181/jaip.v6i1.671

Issue

Volume 6 No. 1, Mei 2018

Section

Article

License

Authors who publish with Jurnal Agro Industri Perkebunan agree to the following terms:

Authors retain copyright and grant the Jurnal Agro Industri Perkebunan right of first publication with the work simultaneously licensed under a Creative Commons Attribution License (CC BY-SA 4.0) that allows others to share (copy and redistribute the material in any medium or format) and adapt (remix, transform, and build upon the material for any purpose, even commercially) with an acknowledgment of the work's authorship and initial publication in Jurnal Agro Industri Perkebunan.

Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in Jurnal Agro Industri Perkebunan. Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work.

Most read articles by the same author(s)